On February 24, 1989, United Airlines flight 811, a Boeing 747-122, experienced an explosive decompression as it was climbing between 22,000 and 23,00 feet after taking off from Honolulu, Hawaii, en route to Sydney, Australia with 3 flight crew, 15 flight attendants, and 337 passengers aboard. The airplane made a successful emergency landing at Honolulu and the occupants evacuated the airplane. Examination of the airplane revealed that the forward lower lobe cargo door had separated in flight and had caused extensive damage to the fuselage and cabin structure adjacent to the door. Nine of the passengers had been ejected from the airplane and lost at sea. A year after the accident, the Safety Board was uncertain that the cargo door would be located and recovered from the Pacific Ocean. The Safety Board decided to proceed with a final report based on the available evidence without the benefit of an actual examination of the door mechanism. The original report was adopted by the Safety Board on April 16, 1990, as NTSB Report AAR-90-01. Subsequently, on July 22, 1990, a search and recovery operation was begun by the U.S. Navy with the cost shared by the Safety Board, the Federal Aviation Administration, Boeing Aircraft Company, and United Airlines. The search and recovery effort was supported by Navy radar data on the separated cargo door, underwater sonar equipment, and a manned submersible vehicle. The effort was successful, and the cargo door was recovered in two pieces from the ocean floor at a depth of 14,200 feet on September 26 and October 1, 1990. Before the recovery of the cargo door, the Safety Board believed that the door locking mechanisms had sustained damage in service prior to the accident flight to the extent that the door could have been closed and appeared to have been locked, when in fact the door was not fully latched. This belief was expressed in the report and was supported by the evidence available at the time. However, upon examination of the door, the damage to the locking mechanism did not support this hypothesis. Rather, the evidence indicated that the latch cams had been back-driven from the closed position after into a nearly open position after the door had been closed and locked. The latch cams had been driven into the lock sectors that deformed so that they failed to prevent the back driving. Thus, as a result of the recovery and examination of the cargo door, the Safety Board's original analysis and probable cause have been modified. This report incorporates these changes and supersedes NTSB Report AAR-90-01. The issues in this investigation centered around the design and certification of the B-747 cargo doors, the operation and maintenance to assure the continuing airworthiness of the doors, cabin safety, and emergency response. As a result of this investigation, the Safety Board issued safety recommendations concerning cargo doors and other nonplug doors on pressurized transport category airplanes, cabin safety, and emergency response.